هل ستصبح شريكنا القادم ؟
Sudhir S. Kapgate and S. R. Satone, Effect of quarry dust as partial replacement of sand in concrete Indian streams research journal, vol.3(5), 2013, ISSN 2230-7850. R Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao, Partial Replacement of Sand with Quarry Dust in Concrete.
WhatsApp: +86 18221755073
grade quarry dust concrete mixes and M40 – 0.41 quarry dust concrete mix can be used for industrial purposes with enhancing the workability and compressive strength than conventional concrete mixes. Further, it is concluded that optimized cement quarry dust ratio concrete mixes are cost-effective compared to conventional concrete mixes ...
WhatsApp: +86 18221755073
By exchanging some of the sand in concrete for quarry dust, compressive strength can be measured for a range of percentages and grades of the material. …
WhatsApp: +86 18221755073
The main aim of this paper is to strengthen the concrete with the fractional replacement of cement by granite dust and replacing the river sand with manufactured sand. The current study is carried out by fractional replacement of cement with granite dust in varying proportions of 0%, 5%, 10%, 15%, and 20% by weight of the cement and …
WhatsApp: +86 18221755073
The choice of quarry dust as replacement for sand has been supported in the previous study (Manassa, 2010) showing that up to 20% of sand has been effectively replaced by quarry dust in traditional concrete. Ilangovan et al. (2008) reported that the strength of quarry rock dust concrete was comparably 10-12% more
WhatsApp: +86 18221755073
-The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material to sand as fine aggregates in the production of concretes especially in Concrete. Quarry dust, a by-product from the crushing process during quarrying activities is one of such …
WhatsApp: +86 18221755073
Quarry dust satisfies the reason behind the alternative material as a substitute for sand at very low costIt is found that 40% replacement of fine aggregate by quarry dust gives maximum result in ...
WhatsApp: +86 18221755073
Quarry rock dust (QRD), a waste obtained during the quarrying process is a significant source of air pollution yet has the potential of becoming a sustainable and economical alternative to sand in concrete. Studies confirmed that replacing sand in conventional concrete with QRD increases its durability and robustness by ten percent.
WhatsApp: +86 18221755073
The compressive strength of cubes at 28 day curing for control mixture of 1:3:6 at 0% partial replacement of river sand with quarry dust was 12.6N/mm2 but compressive strengths of 21.5 N/mm2 and ...
WhatsApp: +86 18221755073
The demand of natural sand in the construction industry has increased a lot resulting in the reduction of sources and an increase in price. Thus an increased need to identify a suitable substitute, that is eco-friendly and inexpensive quarry dust being extensively used as an alternative to the sand in the production of concrete. In this paper an attempt has been …
WhatsApp: +86 18221755073
International Journal of Research Publication and Reviews, Vol 4, no 8, pp 868-871 August 2023 ... ISSN 2582-7421 Review-Experimental Investigation on Quarry Dust as a Partial Replacement of Sand for M-40 Grade Concrete 1Pankaj Prajapati, 2Ankita Agnihotri, ... replacement of sand with quarry dust Bruce Roy Thulane Vilane1 et al ...
WhatsApp: +86 18221755073
-The reduction in the sources of natural sand and the requirement for reduction in the cost of concrete production has resulted in the increased need to identify substitute material …
WhatsApp: +86 18221755073
The most common type of alternative materials that are applying to substitute the sand in concrete is quarry dust, crushes and, manufactured sand, stone dust. Among all of the various alternative cementitious materials, sugarcane bagasse ash and quarry dust are the most readily available and are employed extensively by various …
WhatsApp: +86 18221755073
The use of. quarry dust in concrete is desirable because of its benefits such as useful disposal of byproducts, reduction of river …
WhatsApp: +86 18221755073
The suitability of quarry dust as alternative material for the river sand in concrete manufacturing is studied. M25 grade concrete was prepared with 0%, 20%, 40%, 60%, 80% partial replacement of ...
WhatsApp: +86 18221755073
Karthicket al (2014), in his study on the usage of quarry dust as a partial replacement for sand in concrete found that the compressive strength of concrete cubes at 28 days of …
WhatsApp: +86 18221755073
The compressive strength of concrete which contained 50 to 60% quarry dust in place of natural sand yielded higher strength compared to conventional concrete [37,38]. Published literature show wide-ranging studies on physical, mechanical characteristics and durability aspects of conventional concrete and self-compacting …
WhatsApp: +86 18221755073
chemical properties, workability of the quarry dust concrete, with different ratios of 0%, 20%, 30%&40% for M20 grade of concrete behavior of quarry dust reinforced cement …
WhatsApp: +86 18221755073
and split tensile strength were also higher for the partial replacement of sand either with quarry dust or M sand (Table 2). The increase in compressive strength, split tensile strength and flexural strength Table 1: Properties of fine aggregate used. Properties N sand Quarry dust M sand Fineness modulus 2.25 2.56 2.7 Specific gravity 2.67 1.77 ...
WhatsApp: +86 18221755073
EXPERIMENTAL INVESTIGATION A. Mix proportioning Two grades of concrete M20 and M25 having nominal mix proportion of 1:1.5:3 and 1:1:2 respectively were used by weight and w/c ratio was fixed according to the slump requirement of 60mm. For this concrete mix, quarry dust was added for replacement of sand from 0% to in step of 10%.
WhatsApp: +86 18221755073
The compressive strength test both conventional and replacement materials added concrete was performed on standard compression testing machine of 3000kN capacity, as per IS: 516- SLUMP CONE TEST: The measured slump values of quarry dust with constant water/cement ratio i.e. w/c ratio (0.5) are 65, 66,71,80mm for different mixes …
WhatsApp: +86 18221755073
The objective of the present project work is to study the behavior of concrete in partial replacement for cement with quarry dust in proportions. Quarry dust a waste from the quarry processing ...
WhatsApp: +86 18221755073
river sand. Quarry dust and Marble powder contains similar properties as that of river sand and hence accepted as a building material. The present paper focuses on investigating maximum percentage replacement of river sand by Quarry dust and Marble powder in varying equal percentages 0%, 10%, 20%, 30%, 40%, 50%, and 60% for M25 mix …
WhatsApp: +86 18221755073
This waste problem may be avoided as it could be converted into useful application in concrete production. 2.3 Concrete with quarry dust as fine aggregate In a study in Thailand by Khamput [29] on the compressive strength of concrete using quarry dust as fine aggregate and mixing with admixture type E, it was found that with 70% quarry …
WhatsApp: +86 18221755073
The quarry dust has been used as a partial replacement for cement proportion at different levels of replacement (25%, 30% and 35%). Quarry dust was …
WhatsApp: +86 18221755073
Quarry dust can be used as. an admixture in concrete efficiently to lessen its impact on. environment and human. It can also be used as partial. replacement of cement in concrete. Cement can be ...
WhatsApp: +86 18221755073
For considering M60 grade concrete the Quarry Dust is replaced to natural sand directly i.e. maintained constant & steel fiber are varied in the percentage of 0.5%, 1%, & 1.5% the test were ...
WhatsApp: +86 18221755073
International Journal of Innovative Technology and Exploring Engineering (IJITEE) ISSN: 2278-3075, Volume-2, Issue-6, May 2013 Partial Replacement of Sand with Quarry Dust in Concrete Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao Abstract--The reduction in the sources of natural sand and the …
WhatsApp: +86 18221755073
The regression analysiswas also carried out for the case of concrete with the replacement percentage of the quarry dust. The experimental results is obtainedfor the case of replacing natural sand by the quarry dust, it is observed that there is improvement in the strength of flexurerelated to the concrete.
WhatsApp: +86 18221755073
Chandana Sukesh, Katakam Bala Krishna, P.Sri Lakshmi Sai Teja, S.Kanakambara Rao, 'Partial Replacement of Sand with Quarry Dust in Concrete', International Journal of Innovative Technology and ...
WhatsApp: +86 18221755073
